EFFECT OF WELDED STRUCTURE ON THE STRENGTH OF THE AIRHSIP MEMBRANE

CHEN Zheng; ZHAO HaiTao; HUANG JiPing; CHEN JiAn

doi:10.16579/j.issn.1001.9669.2021.04.008

您当前的位置：

首页 >

文章列表页 >

EFFECT OF WELDED STRUCTURE ON THE STRENGTH OF THE AIRHSIP MEMBRANE

更新时间：2022-09-22

- EFFECT OF WELDED STRUCTURE ON THE STRENGTH OF THE AIRHSIP MEMBRANE
- Journal of Mechanical Strength Vol. 43, Issue 4, Pages: 814-820(2021)
- 作者机构：
  
  1. 上海交通大学航空航天学院
- 作者简介：
- 基金信息：
- DOI：10.16579/j.issn.1001.9669.2021.04.008
  CLC：
扫描看全文
CHEN Zheng, ZHAO HaiTao, HUANG JiPing, et al. EFFECT OF WELDED STRUCTURE ON THE STRENGTH OF THE AIRHSIP MEMBRANE. [J]. 43(4):814-820(2021)
DOI：

CHEN Zheng, ZHAO HaiTao, HUANG JiPing, et al. EFFECT OF WELDED STRUCTURE ON THE STRENGTH OF THE AIRHSIP MEMBRANE. [J]. 43(4):814-820(2021) DOI： 10.16579/j.issn.1001.9669.2021.04.008.

摘要

为了研究飞艇中焊接带结构的材料属性及该结构对蒙皮强度的影响,基于飞艇制作的工程经验和结构的应力分析结果,借助数字图像相关技术,设计了焊接带的单轴拉伸、单轴循环和双轴拉伸的试验试件和试验方案。实验结果表明,和蒙皮相比,焊接带结构的强度相对较大,发生断裂的位置是二者相接处的蒙皮。焊接带结构的存在导致蒙皮强度比原来有所降低,单轴拉伸时强度降低12%左右,双轴拉伸时,拉伸比例为2∶1条件下强度减弱最多,降低36%左右。研究内容能在一定程度上为飞艇整体结构的强度预报提供实验支撑。

Abstract

In order to investigate the material properties of the welded structure in the airship and the effect of the welded structure on the membrane strength,the test specimens and schemes were designed for uniaxial tensile test,uniaxial cyclic test,and biaxial tensile test according to the airship engineering experience and structural stress distribution. The method of digital image correlation was adopted in the experiment. The test results show that the strength of welded structure is more than membrane and the fracture location is the membrane where the two materials meet. The strength of membrane with welded structure is smaller than the membrane itself,which is reduced by about 12% under uniaxial tensile condition and reduced by about 36% under biaxial tensile condition with ratio 2 ∶1. This paper can provide experimental support for the strength prediction of the airship structure.

关键词

焊接带膜结构飞艇强度试验数字图像相关

Keywords

Welded structureMembraneAirshipStrength testDigital image correlation

references

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

STRENGTH ANALYSIS AND TEST OF FABRIC REINFORCED AIRSHIP ENVELOPE (MT)

STUDY ON THE CAGE STRENGTH OF CONSTANT VELOCITY JOINT UNDER LIMIT ANGLE

A J-INTEGRAL MEASUREMENT METHOD BASED ON DIGITAL IMAGE CORRELATION

Related Author

No data

Related Institution

The23rd Institute of China Electronics Technology Corporation

Space Structure Research Center, Shanghai Jiaotong University

College of Mechanical Engineering, University of Shanghai for Science and Technology

School of Mechanical Engineering,Dalian University of Technology

⁰