STUDY ON FREQUENCY DEVIATION OF OUTER RING DEFECT OF BALL BEARINGS CAUSED BY TEMPERATURE-VARIABLE GAP

XIA Bingxin; WANG Dan; SHANG Li; FAN Lei; XING Zhihui; GAO Guowei

doi:10.16579/j.issn.1001.9669.2025.10.004

您当前的位置：

首页 >

文章列表页 >

STUDY ON FREQUENCY DEVIATION OF OUTER RING DEFECT OF BALL BEARINGS CAUSED BY TEMPERATURE-VARIABLE GAP

·Vibration·Noise·Monitoring·Diagnosis· | 更新时间：2025-10-31

- STUDY ON FREQUENCY DEVIATION OF OUTER RING DEFECT OF BALL BEARINGS CAUSED BY TEMPERATURE-VARIABLE GAP
- Journal of Mechanical Strength Vol. 47, Issue 10, Pages: 36-42(2025)
- 作者机构：
  
  沈阳城市建设学院机械工程学院，沈阳 110167
- 作者简介：
  
  XIA Bingxin, E-mail: 17604136033@163.com
- 基金信息：
  
  Foundation of Liaoning Provincial Department of Education(LJKXM202109)
- DOI：10.16579/j.issn.1001.9669.2025.10.004
  CLC： TH133.33
- Received：14 June 2023，
  
  Revised：2024-02-23，
  
  Published：15 October 2025
- 稿件说明：
移动端阅览
夏冰新，王丹，商丽，等. 温变间隙引起球轴承外圈缺陷频率偏差的研究［J］. 机械强度，2025，47（10）：36-42.

XIA Bingxin，WANG Dan，SHANG Li，et al. Study on frequency deviation of outer ring defect of ball bearings caused by temperature-variable gap［J］. Journal of Mechanical Strength，2025，47（10）：36-42.
夏冰新，王丹，商丽，等. 温变间隙引起球轴承外圈缺陷频率偏差的研究［J］. 机械强度，2025，47（10）：36-42. DOI： 10.16579/j.issn.1001.9669.2025.10.004.

XIA Bingxin，WANG Dan，SHANG Li，et al. Study on frequency deviation of outer ring defect of ball bearings caused by temperature-variable gap［J］. Journal of Mechanical Strength，2025，47（10）：36-42. DOI： 10.16579/j.issn.1001.9669.2025.10.004.

摘要

宽温域内轴与球轴承间的间隙随温度升高而增大，同时轴承内部间隙也随温度变化而变化，轴承内圈受到增大的摩擦力矩，使内圈转速降低，从而导致外圈缺陷特征频率出现偏差，不利于球轴承的故障诊断和设备的稳定运行。考虑轴与轴承间的温变间隙，建立了宽温域内含外圈缺陷的轴承动力学模型，分析了模型的时域波形和频谱。仿真和试验结果表明，轴承振动随温度升高而加剧，外圈缺陷特征频率随温度升高而降低。根据工艺要求，适当增加轴与轴承间的过盈量，有利于降低宽温域内轴承系统的振动，提高轴承缺陷频率识别的准确性。研究结果为球轴承在宽温域的使用和健康监测提供了参考。

Abstract

The gap between the rotor and the ball bearing in a wide temperature range increases with the increase in temperature. At the same time

the internal clearance of the bearing changes with the temperature. The inner ring of the bearing is subject to increased friction torque

which reduces its speed. This results in the deviation of the characteristic frequency of the outer ring defect

which is not conducive to the fault diagnosis of the ball bearing and the stable operation of the equipment. Considering the temperature-variable gap between the rotor and the bearing

a dynamic model of the bearing with an outer ring defect in a wide temperature range was established. The time-domain waveform and frequency of the model were analyzed. The simulation and test results show that the bearing vibration increases with the temperature

and the characteristic frequency of the outer ring defect decreases with the increasing temperature. Properly increasing the interference between the rotor and the bearing according to process requirements is beneficial for reducing the bearing system vibration in a wide temperature range and improving the accuracy of bearing defect frequency identification. The results provide reference for the use and health monitoring of ball bearings in a wide temperature range.

关键词

Keywords

references

XU H Y ， WANG P F ， MA H ， et al . Analysis of axial and overturning ultimate load-bearing capacities of deep groove ball bearings under combined loads and arbitrary rotation speed ［J］. Mechanism and Machine Theory ， 2022 ， 169 ： 104665 .

ZHANG P Y ， CHEN C Z . Wind turbine planetary gearbox fault diagnosis using circular pitch cyclic vector and a bidirectional gated recurrent unit ［J］. Measurement Science and Technology ， 2023 ， 34 （ 1 ）： 015105 .

SHI H T ， BAI X T ， ZHANG K ， et al . Spalling localization on the outer ring of hybrid ceramic ball bearings based on the sound signals ［J］. IEEE Access ， 2019 ， 7 ： 134621 - 134634 .

ZHANG K ， FAN C Z ， ZHANG X C ， et al . A hybrid deep-learning model for fault diagnosis of rolling bearings in strong noise environments ［J］. Measurement Science and Technology ， 2022 ， 33 （ 6 ）： 065103 .

BAI X T ， SHI H T ， SUN J ， et al . Localization of double spalling on the outer rings of paired ball bearings by time-delay sound analysis ［J］. Measurement Science and Technology ， 2021 ， 32 （ 9 ）： 094002 .

DARMO S ， BAHIUDDIN I ， HANDOKO P ， et al . Failure analysis of double-row tapered roller bearing outer ring used in Coal Wagon Wheelset ［J］. Engineering Failure Analysis ， 2022 ， 135 ： 106153 .

SHI H T ， LI Y Y ， BAI X T ， et al . Investigation of the orbit-spinning behaviors of the outer ring in a full ceramic ball bearing-steel pedestal system in wide temperature ranges ［J］. Mechanical Systems and Signal Processing ， 2021 ， 149 ： 107317 .

SHI H T ， BAI X T ， ZHANG K ， et al . Effect of thermal-related fit clearance between outer ring and pedestal on the vibration of full ceramic ball bearing ［J］. Shock and Vibration ， 2019 ， 2019 ： 8357807 .

BAI X T ， ZHENG H ， WANG Z N ， et al . Investigation on the misalignment of full ceramic ball bearing rotor system caused by varying gap in wide temperature ranges ［J］. Proceedings of the Institution of Mechanical Engineers ，Part C：Journal of Mechanical Engineering Science， 2024 ， 238 （ 13 ）： 6158 - 6169 .

WU Y H ， YAN H P ， LI S H ， et al . Calculation on the radiation noise of ceramic ball bearings based on dynamic model considering nonlinear contact stiffness and damping ［J］. Journal of Sound and Vibration ， 2020 ， 479 ： 115374 .

BAI X T ， SHI H T ， ZHANG K ， et al . Effect of the fit clearance between ceramic outer ring and steel pedestal on the sound radiation of full ceramic ball bearing system ［J］. Journal of Sound and Vibration ， 2022 ， 529 ： 116967 .

CAO H R ， SHI F ， LI Y M ， et al . Vibration and stability analysis of rotor-bearing-pedestal system due to clearance fit ［J］. Mechanical Systems and Signal Processing ， 2019 ， 133 ： 106275 .

XU H Y ， WANG P F ， YANG Y ， et al . Effects of supporting stiffness of deep groove ball bearings with raceway misalignment on vibration behaviors of a gear-rotor system ［J］. Mechanism and Machine Theory ， 2022 ， 177 ： 105041 .

LIU Z M ， BAI X T ， SHI H T ， et al . A recognition method for crack position on the outer ring of full ceramic bearing based on the synchronous root mean square difference ［J］. Journal of Sound and Vibration ， 2021 ， 515 ： 116493 .

BAI X T ， ZHENG H ， WANG Z N ， et al . Raceway defect frequency deviation of full-ceramic ball bearing induced by fit clearance in wide temperature ranges ［J］. Shock and Vibration ， 2021 ， 2021 （ 1 ）： 6650798 .

罗哉，费业泰，苗恩铭 . 稳态温度场中孔形零件受热变形研究［J］. 材料热处理学报， 2004 ， 25 （ 2 ）： 25 - 27 .

LUO Zai ， FEI Yetai ， MIAO Enming . Study on thermal deformation of hollow piece in steady temperature field ［J］. Transactions of Materids and Heat Treatment ， 2004 ， 25 （ 2 ）： 25 - 27 . （In Chinese）

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

DYNAMIC ANALYSIS OF TBM DRIVING SYSTEM IN UNCERTAIN GEOLOGY

MOTION STABILITY ANALYSIS OF FOUR ROTOR AIRCRAFT BASED ON LYAPUNOV INDEX METHOD

CALCULATIONAL ANALYSIS AND EXPERIMENTAL RESEARCH ON STABILITY OF THE ROD OF CONCRETE-PUMP TRUCK’S BOOM SYSTEM

EXPERIMENTAL RESEARCH ON DIAMOND WHEEL DRESSING BASED ON DYNAMIC MODEL

VIBRATION OPTIMIZATION AND CONTROL OF SEVEN-AXLE HYBRID COUPLING HYDRO-PNEUMATIC SUSPENSION VEHICLE

Related Author

ZHU QingDong

TANG MingJun

SUN Shuai

YUE HongXu

WU BinXing

XIE YuanMing

CHI YuLun

TAN ShaoDong

Related Institution

Academy of Fine Arts,Anshan Normal College

College of Electric and IT,Yangzhou Polytechnic Institute

Institute of Information ＆ Control,Nanjing University of Information Science ＆ Technology

ZOOMLION Co. Ltd.

School of Mechancial Engineering,University of Shanghai for S＆T

⁰